Let the frustration begin!!!! grrrrr

[ChicagoRocket]

Update...

running pretty dam good but I'm still getting a very very slight hesitation up around 6k rpm now...very intermittent. Only did it twice on a 40 minute ride and only seems to do it in 1st gear.

I don't know what to think at this point...the bike runs excellent 99 percent of the time...any thoughts...not sure where to go next!

 

[ChicagoRocket]

Ok gang...ive decided to take the bike into the dealer to have them diagnose it...I will explain to them I am heavily leaning toward the TPS etc. It is under warranty for another year.

Has anyone had the dealer give them trouble for installing a PC5 or the ram air?

 

[Nat67]

I really don't think the dealer is going to be much help here ! All they can do is check your iscv and tps and more than likely blame all on the pcv ?
I was having similar problems until I balanced up the tbs and did the iscv reset .
Tune ECU is the way to go here and save yourself heaps of money . The pcv is a great bit of kit but you do need a decent tuner with a dyno to get the best from them I have found !

 

[ChicagoRocket]

I really don't think the dealer is going to be much help here ! All they can do is check your iscv and tps and more than likely blame all on the pcv ?
I was having similar problems until I balanced up the tbs and did the iscv reset .
Tune ECU is the way to go here and save yourself heaps of money . The pcv is a great bit of kit but you do need a decent tuner with a dyno to get the best from them I have found !

Would you consider this balanced?

 

[Rocket Scientist]

Yep.

 

[ChicagoRocket]

Ok. I'm confused on iscv. I've read everything! Lol. What am I looking for?

 

[ChicagoRocket]

Also. I held the throttle steady at 3k rpm and the tbs were all about even.

 

[ChicagoRocket]

Concerning iscv

Engine off but key on?

Bear claw off so I can make neccessary adjustments if needed?

My secondaries are removed, does this matter?

Please advise. Thanks.

 

[ChicagoRocket]

Eureka!!!! I think I found it!

Is this the process?

http://tuneecu.com/Tunes_in_Hex_and...C_Stepper_Adjustment_A4Rev_02_20120204_EN.pdf

 

[Nat67]

Yes balance is good , altho could be better ! Within 10 of each other is great . Spot on is ideal and achievable.
Iscv and Tps tests are straightforward as are the adjustments .
I have no secondaries either so no issue there .
Any problems and I will repeat to you word for word warps walkthrough !
Incidentally my tbs were roughly in the same ballpark as yours , getting them spot on did make a noticeable difference !