Search results for query: *

  1. Gothlander

    Engine Light

    Check oil sensor on the back of the head, make sure the water pump is turning (this will also check the oil pump drive).
  2. Gothlander

    Transmission Failure

    Change the clutch adjustment dial on the lever to the number 1 setting.
  3. Gothlander

    Stalling while shifting from first to second.

    Raise idle to 850 - 900 Clean crank angle sensor Clean gear position sensor Load latest known good tune Check manifold pressure tubes for leaks/blockages. Use correct fuel/oil Reset throttle before start Balance throttle bodies
  4. Gothlander

    Lower Timing Chain Blew-up!!!!!!!

    Sorry Eric I can't tell you what models are effected.
  5. Gothlander

    Lower Timing Chain Blew-up!!!!!!!

    You will need to remove the sprocket to see if it is flogged.
  6. Gothlander

    Lower Timing Chain Blew-up!!!!!!!

    Did they check the key way on the lower cam chain sprocket? Some have flogged out and caused the rattle.
  7. Gothlander

    Starter will not spin.

    Are the solenoid contacts making good contact?
  8. Gothlander

    Scorpion Battery Issue

    I think you're on to it, gear position sensor.
  9. Gothlander

    No power, stalling and hard start

    A faulty TPS can cause these symptoms, I would suggest looking at the fuel delivery system as well. Spark plugs and coils should be checked. Vacuum hoses and maybe the crank angle sensor cleaned.
  10. Gothlander

    busted Crank!

    This makes me wonder if metal shavings on the crank angle sensor could cause detonation (this may cause blow back). The crank does have a lot of hardware hanging of it so it wants to keep spinning while other forces are trying to stop it.
  11. Gothlander

    I'm fed up now!

    Just connect a wire from the negative terminal on the battery to the handlebars (just to test use a jumper cable) and check that the starter button works. If the handlebars don't for some reason have a ground wire it will have to take what ever path is available. This can be through the...
  12. Gothlander

    I'm fed up now!

    Ok this might work, the button works by grounding the black wire. Try connecting a ground to the handlebars as it may not have one because of the mods.
  13. Gothlander

    Rear brakes disappeared

    Change the brake fluid asap or it will happen again !!! When the fluid gets old it absorbs moisture and when it gets hot it turns to gas.
  14. Gothlander

    Easy high/poor idle fix

    If it has the black internals the primary TPS usually will go bad. I adjusted my TPS by hand when I had the same problem but found it did eventually go bad within days.
  15. Gothlander

    Bear Claw Over Triple Filters

    You can do what I did and space the bearclaw out by 20mm,up by 20mm then fit a rubber moulding to the top edge (this reduces the chirping as well). This will also allow you to lift your tank without removing the Claw.
  16. Gothlander

    Took Headlight fuse out to upload, and afterwards no start.

    Put the fuse back in and check you kill switch. The headlight fuse is also the starter fuse.
  17. Gothlander

    Turn the key on and no power!!

    They are on a separate circuit to the headlights, they are powered through the ignition with the indicators, brake-lights and horn. You will notice all these are available in park.
  18. Gothlander

    Turn the key on and no power!!

    I tried to tell eastern beaver years ago that he could have just made a plug and play kit but he would not listen. The wires to the headlight are ok and don't need replacing, all he needed to do was plug in between the headlight plug on the loom and to the plug that connects to it. I think he...
  19. Gothlander

    Diff Oil Leak

    Not sure how it fits together but maybe a damaged seal or the surface where the seal sits is damaged causing a leak. Maybe the way wheel is fitted is damaging the seal.
  20. Gothlander

    Diff Oil Leak

    Can you at least tell us where it is leaking from ?
Back
Top